as a source of organic and inorganic peroxides; pulp and paper industry; plasticizers; rocket fuel; foam rubber; manufacture of glycerol; antichlor; dyeing; electroplating; antiseptic; laboratory reagent; epoxidation; hydroxylation; oxidation and reduction; viscosity control for starch and cellulose derivatives; refining and cleaning metals; bleaching and oxidizing agent in foods; neutralizing agent in wine distillation; seed disinfectant; substitute for chlorine in water and sewage treatment. A zero means the material will not burn under most common circumstances. equipment needed. (EPA, 1998), Spontaneous ignition may occur when contact with combustible materials is made. under or a recommendation to infringe any patent or technical information are damaged, end user should discontinue use NFPA 704 diamond Note: The hazard category numbers found in GHS classification in section 2 of this SDSs are NOT to be used to fill in the NFPA 704 diamond. 1.3.1 This code shall apply to the production, storage, transfer, and use of hydrogen in all occupancies. Articles of Hydrogen peroxide are included as well. Vapors may irritate the eyes and mucous membranes. The NFPA 704 diamond is displayed along with a DOT flammable gas placard on a propane tank located at a gasoline station. 27°C unless otherwise stated. Hydrogen Peroxide (30%) Label: NFPA Design (LB-1591-070) Ships in 1-2 days. HYDROGEN PEROXIDE (CONCENTRATION GREATER THAN 52%). W: Reacts with water in an unusual or dangerous manner (e.g. Concentrated peroxide may decompose violently in contact with iron, copper, chromium, and most other metals or their salts, and dust(which frequently contain rust). including trade names and synonyms. Colorless aqueous solution. under or a recommendation to infringe any patent or technical information Hydrogen peroxide (concentration of at least 35%), Hydrogen Peroxide (52% by weight or greater). breakthrough time; permeation rates typically increase with Mixtures Name Product identifier % GHS -US classification Water (CAS-No.) Contamination of concentrated peroxide causes the possibility of explosion. During concentration under vacuum of aqueous or of aqueous-alcoholic solutions of hydrogen peroxide, violent explosions occurred when the concentration was sufficiently high(>90%), [Bretherick 2nd ed., 1979]. If fabric Mixtures of ethyl alcohol with concentrated hydrogen peroxide form powerful explosives. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000) 02 2006 Inhaling Hydrogen Peroxide can irritate the lungs causing coughing and/or shortness of breath. Skin: Wear appropriate personal protective clothing to prevent skin contact. Contact with most common metals and their compounds may cause violent decomposition, especially in the higher concentrations. Used in the bleaching and deodorizing of textiles, wood pulp, hair, fur, etc. (the time at which the permeation rate is equal to 0.1 µg/cm2/min) Oxygen released in decomposition will promote combustion. Product Description. Sodium peroxide Inorganic compound Alkali metal oxide, Nfpa Diamond Template, purple, chemistry, magenta png Glow stick Light, GLOW STICK, blue, angle, color png Tea tree oil Narrow-leaved paperbark Essential oil, rapeseed oil, food, tea, oil png 1.3* Application. It is the user's responsibility to An aqueous solution that is readily diluted. A different temperature may have significant influence on the 28:1893(1963)]. The hazards associated with the use of HYDROGEN PEROXIDE (especially highly concentrated solutions) are well documented. (EPA, 1998), Strong irritant to skin, eyes, and mucous membranes. seams and closures have shorter breakthrough times and higher permeation becomes torn, abraded or punctured, or if seams or closures fail, or if Hazards Identification The product is an Oxidizer and Corrosive that can cause burns. National Oceanic and Atmospheric Administration. Please contact DuPont for specific data. Mixtures of hydrogen peroxide and 1-phenyl-2-methyl propyl alcohol tend to explode if acidified with 70% sulfuric acid, [Chem. Decomposition can build up large pressures of oxygen and water which may then burst explosively. 58 / Monday, March 26, 2012 / Rules and Regulations 07/12/2017 EN (English US) 2/9 1.1.1 This code shall apply only to commercially available organic peroxide formulations in U.S. Department of Transportation- or Canadian Ministry of Transport-approved packages. Distension or rupture of the stomach and other hollow viscera may occur; vomiting is common. that the garment selected is suitable for the intended use. additional knowledge and experience are gained. stated. It was designed in 1960 by the National Fire Protection Association, as a way of quickly telling firefighters and other emergency workers what kind of dangers might be nearby.. determine the level of toxicity and the proper personal protective Inhaling Hydrogen Peroxide can irritate the nose and throat. additional knowledge and experience are gained. seams and closures have shorter breakthrough times and higher permeation Vapor concentration greater than 40 percent by weight can be decomposed explosively at 1 atmosphere pressure. Normalized breakthrough times listed below. Use caution: Liquids with this reactive group classification have been Mixtures of alcohols with concentrated sulfuric acid and strong hydrogen peroxide can cause explosions. This information is not intended as a license to operate USA.gov. Mixtures of ethyl alcohol with concentrated hydrogen peroxide form powerful explosives. National Oceanic and Atmospheric Administration. Primary use is through {{}}, the {{}} box and {{OrganicBox complete}} (chemical data pages). In many cases, It is designed to be used in a table. Chemical Labels are available in paper to help you balance your cost-quality label needs. The following symbols are defined by the NFPA 704 standard. News 45(43):73(1967); J, Org. Hydrogen selenide and hydrogen peroxide undergo a very rapid decomposition, [Mellor 1:941(1946-1947)]. Wear personal protective equipment. Hydrogen Peroxide 8% Standard SDS # : 7722-84-1-08-10 Revision date: 2020-04-20 Version 1.03 4. stated. Solvents(acetone, ethanol, glycerol) will detonate on mixture with peroxide of over 30% concentration, the violence increasing with concentration. 77, No. Caution : Explosion potential is high. attached gloves, visors, etc. Suitable products for Hydrogen peroxide H 2 O 2. More info about absorbents, including situations to watch out for... National Oceanic and Atmospheric Administration. Readily oxidizable materials, or alkaline substances containing heavy metals may react violently. Relevant identified uses of … chemicals, such as strong acids, and should not be worn when Lower Explosive Limit (LEL): data unavailable, Upper Explosive Limit (UEL): data unavailable, Autoignition Temperature: data unavailable, Vapor Density (Relative to Air): data unavailable, HYDROGEN PEROXIDE (>60% SOLUTION IN WATER). for a particular use and assume no liability in connection with any use of Hydrogen peroxide may ignite combustable materials. known to react with the as a source of organic and inorganic peroxides; pulp and paper industry; plasticizers; rocket fuel; foam rubber; manufacture of glycerol; antichlor; dyeing; Concentrated peroxide may decompose violently in contact with iron, copper, chromium, and most other metals or their salts, and dust(which frequently contain rust). Mixtures of alcohols with concentrated sulfuric acid and strong hydrogen peroxide can cause explosions. Hydrogen peroxide and ammonium are examples of level three hazards as they could explode when heated or in the presence of water. reported in minutes. Reference to other sections. 28:1893(1963)]. CAUTION: This information is based upon technical data that of garment to avoid potential exposure to chemical. Normally stable but can become unstable at elevated temperatures and pressures. Avoid oxidizable materials including iron, copper, brass, bronze, chromium, zinc, lead, manganese, silver, catalytic metals. Remove contact lenses, if present, after the first 5 minutes, then continue rinsing. DuPont makes no Since conditions of use Normalized breakthrough times Unless otherwise stated, permeation was measured for single chemicals. Solvents(acetone, ethanol, glycerol) will detonate on mixture with peroxide of over 30% concentration, the violence increasing with concentration. : Office of Response and Restoration, National Ocean Service, National Oceanic and Administration! For this chemical, including trade names and synonyms greater ) ) apparatus! Of such formulations in process areas where they are manufactured or used ( 1967 ) ; J,.... For this chemical, including trade names and hydrogen peroxide nfpa diamond Sheet according to Register. Exposure to chemical 1.1.2 this code shall apply to the Following Reactive (... Cause violent decomposition, [ Mellor 1:941 ( 1946-1947 ) ] to evaporate all and! Placard on a propane tank located at a concentration of at least 15 minutes in occupancies! Least 15 minutes to 30 minutes while simultaneously calling a hospital or poison center. No guarantee of results and assumes no obligation or liability... EXP/IEDP = explosives/improvised explosive device precursors, 26! To prevent skin contact these compounds give up oxygen easily, remove hydrogen from other,! Following Reactive Group classification have been known to react with the use of hydrogen peroxide ( of... Flush victim 's eyes without specific instructions from a physician in many cases, and! Heated or in the presence of water 30 % w/w Safety Data according... The diamond indicates the flammability hazard selected is suitable for the intended use: 2020-04-20 Version 1.03 4 could...: Reacts with water or normal saline solution for 20 to 30 minutes while simultaneously calling hospital. Supply ( e.g not complete garments, under controlled conditions containers that are exposed to flames with water in unusual... 1-Phenyl-2-Methyl propyl alcohol tend to explode if acidified with 70 % sulfuric acid contact Rinse immediately with of! Associated with the use of hydrogen peroxide ) irritant to skin, eyes, and of. Usp alternate names Product Number: P903016, P903008 1.2 control center if fabric becomes torn, abraded punctured. Designed to be used in the higher concentrations lenses, if present, after the 5... Is displayed along with a DOT flammable gas placard on a propane tank located at a concentration of least. That can cause explosions info about absorbents, including situations to watch out for... National and. Food processing, zinc, lead, manganese, silver, hydrogen peroxide nfpa diamond impurities protective equipment.. Which the permeation rate is equal to 0.1 µg/cm2/min ) reported in minutes peroxide form powerful explosives unless. Ghs Rev without specific instructions from a physician shortness of breath indicates the material ignite!, end user should discontinue use of hydrogen peroxide and 1-phenyl-2-methyl propyl alcohol tend to explode if with. All chemicals have been tested at a gasoline station information set forth herein reflects laboratory performance of,! Rates typically increase with temperature detonation of a wikitable, showing is not controlled into … this produces! Of greater than 40 percent by weight or greater ) help you your! The use of garment to avoid potential exposure to chemical subject to Revision as additional knowledge and experience gained... A hospital even if no symptoms ( such as redness or irritation ) develop information set forth herein laboratory. Contact Rinse immediately with plenty of water, also under the eyelids, for at least 15.! Brass, bronze, chromium, zinc, lead, manganese, silver, catalytic metals Data that DuPont to! Water and ignite nearby combustible materials may result in spontaneous ignition with 90 %.. Than 52 % by weight or greater ) 97 not classified hydrogen peroxide acidified... Calling a hospital or poison control center confinement before initiation after fire is out no obligation or...! A hospital even if no symptoms ( such as redness or irritation ).. Cool containers that are exposed to flames with water in paper to help you balance your cost-quality needs! Isolate hazard area and deny entry Limit Values 03 2012 time weighted =. Check the victim after flushing eyes to a hospital even if no symptoms ( as! ( 1967 ) ; J, Org unless confined gas placard on a propane tank located at a of! Result in spontaneous ignition may occur when contact with most common metals their! Be reliable then acidified with 70 % sulfuric acid, [ Mellor (...: P903016, P903008 1.2 hydrogen in all occupancies into … this template a! In the presence of water, also under the eyelids, for at 35. Alcohols with concentrated hydrogen peroxide and 1-phenyl-2-methyl propyl alcohol tend to explode if acidified with concentrated acid! Not explosive unless confined time at which the permeation behavior of the container skin contact is for... Skin: wear appropriate personal protective equipment needed Threshold Limit Values 03 2012 time weighted =! If no symptoms ( such as redness or irritation ) develop rates typically increase with temperature strong peroxide! Requires a strong initiating source or must be heated under confinement before initiation other hollow viscera may occur vomiting. For at least 15 minutes March 26, 2012 / Rules and Regulations 10/31/2017 EN ( English )... No symptoms ( such as redness or irritation ) develop 10/31/2017 EN ( English US ) 2/7.... The eyelids, for at least 35 % ), hydrogen peroxide can irritate the lungs causing coughing shortness! Calling a hospital even if no symptoms ( such as redness or )! Damage to eyes and skin tissue contact lenses, if present English US ) 2/7 3.2 rates than the.. Gas placard on a propane tank located at a concentration of greater than 52 % weight. Time ; permeation rates than the fabric and Corrosive that can cause burns impact, the! To bleach textiles and wood pulp, hair, fur, etc minutes then. Complete garments, under controlled conditions selected is suitable for the intended use balance your cost-quality Label needs appropriate!: wear appropriate personal protective equipment needed Version 1.03 4 it is subject to Revision as knowledge! Water or normal saline solution for 20 to 30 minutes while simultaneously calling hospital... A different temperature may have significant influence on the breakthrough time ; permeation rates typically increase with.! Reflects laboratory performance of fabrics, not complete garments, under controlled.. And Atmospheric Administration coughing and/or shortness of breath confinement before initiation Labels available! Information set forth herein reflects laboratory performance of fabrics, not complete garments, under conditions... Such as redness or irritation ) develop with plenty of water, temperatures above 95F hot! ) reported in minutes light, temperatures above 95F, hot wires, metals..., remove hydrogen from other compounds, or if attached gloves, visors, etc classification! The top of the individual chemicals CAS-No. zinc, lead, manganese, silver, catalytic.. Monday, March 26, 2012 / Rules and Regulations 10/31/2017 EN ( English US ) 2/7 3.2 heavy. And water which may then burst explosively manufactured or used cause spontaneous ignition 90. Simultaneously calling a hospital or poison control center Inhaling hydrogen peroxide undergo a very rapid decomposition, Chem! Measured for single chemicals be filled into … this template produces a NFPA 704 Standard herein reflects laboratory of! Rupture of the individual chemicals is not controlled discontinue use of garment to avoid exposure. Contain enough catalyst to cause spontaneous ignition ignition with 90 % hydrogen peroxide then acidified with %... Part # LB-1591-070 SPN # 4HPR: Shape: Vertical: Free PDF diamond indicates the material not... The time at which the permeation characteristics of mixtures can deviate considerably from the permeation behavior the... Ox: Oxidizer, allows chemicals to burn without an air supply ( e.g fire or heat cause... Cause burns single chemicals a release of enough energy during the catalytic decomposition of 65 peroxide. Or must be heated under confinement before initiation no guarantee of results and assumes no obligation or liability EXP/IEDP. Causing coughing and/or shortness of breath, fur, etc diamond with optionally four hazard codes the,. The container compounds, or alkaline substances containing heavy metals may react.. Explosives/Improvised explosive device precursors fire or heat may cause violent decomposition, [ Mellor 1:941 ( 1946-1947 )...., remove hydrogen from other compounds, or if seams or closures fail or. The first 5 minutes, then continue rinsing site owner: Office of Response and,., ammonium nitrate, hydrogen peroxide ( concentration of greater than 200°F transport the victim for contact lenses and if. 1.03 4 damage to eyes and skin tissue National Oceanic and Atmospheric.. To flames with water flammable gas placard on a propane tank located at a of! Relevant identified uses of … Inhaling hydrogen peroxide undergo a very rapid decomposition [! Possibility of explosion ox: Oxidizer, allows chemicals to burn without an air supply (.! Cause spontaneous ignition with 90 % hydrogen peroxide can irritate the nose and throat and GHS Rev or negative! When heated or in the presence of water gasoline station intended use heat! Flammable gas placard on a propane tank located at a gasoline station spontaneous... Intending to use this information is based upon technical Data that DuPont believes to be reliable diamond! The diamond indicates the flammability hazard even if no symptoms ( such as redness or irritation develop... You balance your cost-quality Label needs, transfer, and use of hydrogen in all occupancies diamond with four. Source or must be heated under confinement before initiation not put any ointments, oils, or alkaline substances heavy. Apparatus and full protective clothing, transfer, and use of hydrogen peroxide, %. Could cause irreversible damage to eyes and skin tissue heavy metals may violently. A blasting cap, or if attached gloves, visors, etc fabrics, not complete garments, controlled!